Abstract The aim of this investigation was to evaluate the impact of multiple freezing and thawing cycles on the physicochemical properties of Nile tilapia fillets. For this purpose, 72 fresh Nile tilapia fillets were packed and stored in a freezer at -18 °C. The frozen samples were submitted to five freeze-thaw cycles; in each cycle, the freezer was switched off during 14 hours. The consecutive freeze-thaw cycles resulted in a fillet’s total weight loss of 9.48%, with a quadratic regression (P < 0.0001) for thaw loss, with a greater loss percentage in cycle 3 (2.68%). pH values differed between the cycles (P < 0.0001), being observed an increment in this parameter only from cycle 4. The lipid oxidation remained constant in cycles 1, 2, 4 and 5, however in cycle 3 the lowest value (P < 0.0002) was observed. The luminosity, and intensity of the red and yellow colours increased linearly (P < 0.0001) as the cycles increased. Thereby, the tilapia fillets’ quality were adversely affected by the freezing cycles. The unfavourable alterations included weight loss, lipid oxidation and elevated pH, as well as the increasingly augmentation of brightness and red and yellow colorations of fillets as the progressive cycles occurred.

ABSTRACT: This study evaluated pre-slaughter stress and its influence on the stress indicators, quality characteristics and sensory characteristics of Nile tilapia fillets. To this end, two experiments were conducted: (1) two transportation times (60 and 240 min), with a density of 200 kg m−3, were compared to control treatment fish (in which the fish were removed from the net cage and immediately euthanized); and (2) two transportation densities (100 and 400 kg m−3), transported for 180 min, compared with control treatment fish. In experiment 1, the transportation time of 60 min resulted in higher levels of serum cortisol and plasma glucose compared to the transportation time of 240 min and the control. Fish fillets transported for 240 min had higher water-holding capacity, less water loss by pressure and higher levels of juiciness compared to fish transported for 60 min. Color, pH and water loss during cooking were not affected by transportation time. In experiment 2, transportation densities of 100 and 400 kg m−3 did not significantly affect the stress indicators nor the instrumental quality parameters of the fillets, but fish transported at 400 kg m−3 showed better visual acceptance by panellists.

Abstract With the goal of developing and characterizing the nutritional and sensory aspects of fresh pasta supplemented with tilapia protein concentrate, four types of pasta were prepared, with inclusion of 0, 10, 20, or 30% of tilapia protein concentrate. Linear effects were observed (P < 0.01) in crude protein, total lipids, ash, carbohydrate, and caloric values; these parameters increased with increasing amounts of tilapia protein concentrate in the pasta. The concentration of Na, P, Ca, Mg, and Zn increased linearly (P < 0.01) in correlation with the increase in protein concentrate content, while Fe content decreased linearly (P < 0.01). In the sensory analysis, texture, overall impression, and the acceptance index demonstrated a cubic regression (P < 0.05), with the inclusion of 20% protein concentrate yielding the best scores. Including up to 30% of tilapia protein concentrate in pasta yields an increased nutritional value, but based on the sensory results, 20% of tilapia protein concentrate in pasta is the recommended maximum level.